Product ID:VR-3 VINYL RESIN ALUMINUM-A, 112-013A
MSDS Date:06/27/1988
FSC:8010
NIIN:00N020402
Kit Part:Y
MSDS Number: BLRMD

D J SIMPSON COMPANY

111 SOUTH MAPLE AVE
SOUTH SAN FRANCISCO, CA 94080
US

Emergency Phone: 415-873-5990

Info Phone: 415-873-5990

Cage: HO887

SIMPSON D J CO INC

2265 SOUTH SAN FRANCISCO, CA 94080-6303 US

Telephone: 415-873-5990

Cage: 33244

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 25%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ISOAMYL KETONE

CAS: 110-12-3

RTECS: MP3850000

Fraction By Weight: 25%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 9293

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 25 - 30%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TRANSFER. HANDLE WHERE VENT IS ADEQ & AWAY

RTECS: 9999999ZZ

CONTAIN HAZ MATL HENCE IT IS ADVISED TO OBSERVE THIS

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: ANESTH. IRRIT/RESP TRACT
W/HDCH, NAUSEA, DIZZ, UNCONC/COMA. NOTE TO MD: INGEST OF THIS
PROD/SUBSEQUENT VOMIT CAN RSLT IN ASPIR OF LIGHT HYDROCARB LIQ INTO
LUNGS WHICH CAN CAUSE FATAL CHEM PNEUM . RPT/PRLNG OCCUP OVEREXP TO
SOLVS MAY LEAD TO PERM BRAIN/NERVOUS SYS DAM. (ALSO KNOWN AS
PAINTER'S/SOLVENT SYNDROME).
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL:DIZZ, NAUS, HDCH, IRRIT OF RESP TRACT,
UNCONC & EVEN ASPHY AT HIGH CONC. HAS BEEN FOUND THAT TOLUENE
CONTAINS A COMPONENT WHICH CAN CAUSE IRREVERSIBLE CHANGES IN DNA OF
THE CELL. SKIN CONT: IRRI T, DRYING/CRACKING. EYES: IRRIT/EYE BURN.
SKIN ABSORB: SEV IRRIT/ BURNING SENSATION. CRACKING, DEFATTING (SEE
SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING HEART, LUNG, KIDNEY,
LIVER, SKIN DISORDERS.

First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING. ADMINISTER
OXYGEN IF NEEDED. SEEK MD IMMEDIATELY. EYE: FLUSH WITH LARGE
AMOUNTS OF H2O FOR AT LEAST 15 MINUTES WITH LIDS OPEN. SEE MD
IMMEDIATELY. SKIN: WASH WITH SOAP & WATER. REMOVE CONTAMDCLOTHING.
INGEST: DO NOT INDUCE VOMITING. DRINK ONE OR TWO GALSSES OF WATER
TO DILUTE. SEE MD IMMEDIATELY. KEEP PATIENT QUIET, WARM AND
COMFORATABLE.

Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:1.2%
Upper Limits:7%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIP . FIGHT AS VOLATILE LIQ FIRES. USE WATER TO COOL
FIRE EXPOS CNTNRS. AVOID SPREADING FIRE (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. VAPS MAY TRAVEL TO SOURCES OF IGNIT & CAUSE A FLASH
FIRE. ISOLATE FROM ALL SOURCES OF HEAT. (SUPP DATA)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. CONTAIN & REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
WEAR PROTECTIVE EQUIPMENT DURING CLEANUP. CONTAIN LIQUID TO PREVENT
CONTAMINATION OF SOIL AND G ROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CLOSURE TIGHT & CNTNR IN UPRIGHT
POSITION. STORE AWAY FROM HEAT/OTHER SOURCES OF INGIT. CNTNRS MUST
BE GROUNDED &/OR BONDED DURING LIQ (ING 4)
Other Precautions:AVOID PRLNG BRTHG OF VAPS, SKIN/EYE CONT. IN CASE OF
CONT, WASH THOROUGHLY W/SOAP & H2O. CONTAINS >1% BY WT OF
PHOSPHORIC ACID, >0.1% BY WT OF VINYL CHLORIDE, AND VINYL ACETATE.
TOXIC FLAMM IRRITANT.

Respiratory Protection:NIOSH/MSHA APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR.
Ventilation:REQUIRED, 200 CFM MINIMUM.
Protective Gloves:CHEMICALLY RESISTANT PLASTIC OR RUBBER.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & SAFETY SHOWERS IN WORK AREA
RECOMMENDED. USE PROTECTIVE HAND CREAMS TO PREVENT DEFATTING OF
SKIN UPON EXPOS.
Work Hygienic Practices:WASH W/SOAP & WATER, REMOVE CONTAMINATED
CLOTHING BEFORE HANDLING FOOD OR SMOKING. DAILY SHOWERS
RECOMMENDED.
Supplemental Safety and Health
FIRE FIGHT PROC:W/COOLING H2O. FOG NOZZLES FOR H2O RECD. EXPLO
HAZ:EMPTY CNTNRS MAY EXPLODE DUE TO RESIDUES. OBSERVE THIS MSDS.
ALL METAL CNTNRS MUST BE GROUNDED &/OR BONDED DURING LIQ TRANSFER.
HLTH HAZ: & DERM MAY OCCUR ON PRLNG EXPOS. INGEST:DIZZ, NAU. NOT
EXPECTED TO HAVE ACUTE SYSTEMIC TOX BY INGEST.

HCC:F3
Boiling Pt:B.P. Text:232F,111C
Vapor Density:SEE INGRED
Spec Gravity:0.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VISCOUS LIQUID WITH DISTINCT SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS, ACIDS AND BASES.
Stability Condition to Avoid:STORE AWAY FROM HEAT, ELECTRICAL EQUIP,
SPARKS, OPEN FLAME.
Hazardous Decomposition Products:USUAL PRODUCTS OF COMBUSTION: CARBON
DIOXIDE, CARBON MONOXIDE, OTHER OXIDES, SMOKE, FUMES, ETC.

Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.